PRESS-NEWS.org - Press Release Distribution
PRESS RELEASES DISTRIBUTION

Radically simple technique developed to grow conducting polymer thin films

Conductive plastic coatings could lead to new solar cells, windows, sensors

2010-11-03
(Press-News.org) Oil and water don't mix, but add in some nanofibers and all bets are off.

A team of UCLA chemists and engineers has developed a new method for coating large surfaces with nanofiber thin films that are both transparent and electrically conductive. Their method involves the vigorous agitation of water, dense oil and polymer nanofibers. After this solution is sufficiently agitated it spreads over virtually any surface, creating a film.

"The beauty of this method lies in its simplicity and versatility," said California NanoSystems Institute (CNSI) researcher Richard B. Kaner, a professor of chemistry and biochemistry and a professor of materials science and engineering at the UCLA Henry Samueli School of Engineering and Applied Science. "The materials used are inexpensive and recyclable, the process works on virtually any substrate, it produces a uniform thin film which grows in seconds and the entire thing can be done at room temperature."

Conducting polymers combine the flexibility and toughness of plastics with electrical properties. They have been proposed for applications ranging from printed electronic circuits to supercapacitors but have failed to gain widespread use because of difficulties processing them into films.

"Conducting polymers have enormous potential in electronics, and because this technique works with so many substrates, it can be used in a broad spectrum of applications, including organic solar cells, light-emitting diodes, smart glass and sensors," said Yang Yang, a professor of materials science and engineering at the Samueli School of Engineering and Applied Science and faculty director of the Nano Renewable Energy Center at the CNSI.

One of the potential applications is smart, or switchable, glass that can change between states when an electric current is applied — for example, switching between see-through and opaque states to let light in or block it. The UCLA research group is applying the technique to other nanomaterials in addition to polymer nanofibers in the hopes of expanding the number of available applications.

The team's solution-based technique, published in the peer-reviewed journal Proceedings of National Academy of Sciences, was discovered serendipitously when a transparent film of polymer spread up the walls of a container while nanofibers in water were being purified with chloroform.

"What drew me in immediately was the eerie phenomenon of what appeared to be self-propelled fluid flow," said Julio M. D'Arcy, lead author on the PNAS paper and a senior graduate student in the Kaner's UCLA lab.

"Now I can tell people that I make films in L.A.," he joked.

When water and oil are mixed, a blend of droplets is formed, creating a water–oil interface that serves as an entry point for trapping polymer nanofibers at liquid–liquid interfaces. As droplets unite, a change in the concentration of blended solids at the water–oil interface leads to a difference in surface tension. Spreading up a glass wall occurs as result of an attempt to reduce the surface-tension difference. Directional fluid flow leads to a continuously conductive thin film comprised of a single monolayer of polymer nanofibers. The uniformity of the film surface is due to the particles being drawn out of the water–oil interface, sandwiched between two fluids of opposing surface tensions.

Development of the technology is occurring in collaboration with Fibron Technologies Inc., with support from the National Science Foundation through a Small Business Technology Transfer grant. Fibron is a small company that has licensed the technology from UCLA. It was founded by Kaner, who serves as chief scientific adviser, and two of his former Ph.D. students — Christina Baker and Henry Tran, who have gone on to take leadership roles in the company.

Fibron's CEO, Christian Behrenbruch, said "working with UCLA to develop this technology has been a win-win. It enables us to access incredibly innovative people, but also, the NSF has helped enable the establishment of a formal and transparent IP releationship with the university. The good news is that this technology is moving rapidly into commercial development."

Other techniques exist for creating thin films of conducting polymers, but each technique tends to work only a limited number of applications, or they are not feasible for scaling up. A method has long been sought which would overcome the limitations of each of the previous methods. The water and oil technique, with a bit of nanotechnology thrown in, might provide just that — a scalable universal method for creating large thin films of conducting polymers.

INFORMATION: The California NanoSystems Institute at UCLA is an integrated research facility located at UCLA and UC Santa Barbara. Its mission is to foster interdisciplinary collaborations in nanoscience and nanotechnology; to train a new generation of scientists, educators and technology leaders; to generate partnerships with industry; and to contribute to the economic development and the social well-being of California, the United States and the world. The CNSI was established in 2000 with $100 million from the state of California. An additional $850 million of support has come from federal research grants and industry funding. CNSI members are drawn from UCLA's College of Letters and Science, the David Geffen School of Medicine, the School of Dentistry, the School of Public Health and the Henry Samueli School of Engineering and Applied Science. They are engaged in measuring, modifying and manipulating atoms and molecules — the building blocks of our world. Their work is carried out in an integrated laboratory environment. This dynamic research setting has enhanced understanding of phenomena at the nanoscale and promises to produce important discoveries in health, energy, the environment and information technology.

For more news, visit the UCLA Newsroom and follow us on Twitter.


ELSE PRESS RELEASES FROM THIS DATE:

Einstein launches SuperAgers.com to spotlight aging research

2010-11-03
VIDEO: SuperAgers.com website features aging research and video portraits of centenarians. Click here for more information. November 1, 2010 – (BRONX, NY) – Albert Einstein College of Medicine of Yeshiva University has launched SuperAgers.com, a new website that features the latest information on more than a decade of aging research at Einstein. The SuperAgers.com website highlights the work of Nir Barzilai, M.D., director of the Institute for Aging Research and a team of ...

Lombardi research: Robotic radiosurgery offers palliative care for hilar lung tumors

2010-11-03
Washington, DC – Patients report decreased pain and improved breathing following treatment of their hilar tumors with robotic radiosurgery, but researchers say the therapy falls short of improving survival. Still, the study, conducted by researchers at Georgetown Lombardi Comprehensive Cancer Center and presented today at the annual meeting of the American College of Chest Physicians in Vancouver, BC, represents the first of its kind to document the use of radiosurgery for hilar tumors and presents a novel therapy option. For the study, researchers reviewed the ...

In flies, a search for the essence of obesity

2010-11-03
Fruit flies that grow obese after eating a diet loaded with fat could lead the way to the core elements of obesity, according to researchers who report their findings in the November issue of Cell Metabolism, a Cell Press publication. The findings also get at obesity's origins. The demonstration that flies do become obese on a high-fat diet (HFD), much as humans do, indicates that the ability to become obese goes way, way back, the researchers say. "The capacity for obesity is evolutionarily ancient," said Sean Oldham of the Sanford-Burnham Medical Research Institute. ...

Liver hormone is a cause of insulin resistance

2010-11-03
Researchers have identified a hormone produced and secreted by the liver as a previously unknown cause of insulin resistance. The findings, in the November issue of Cell Metabolism, a Cell Press publication, suggest a new target for the treatment of insulin resistance and type 2 diabetes, the researchers say. "The current study sheds light on a previously underexplored function of the liver; the liver participates in the pathogenesis of insulin resistance through hormone secretion," said Hirofumi Misu of Kanazawa University Graduate School of Medical Science in Japan. ...

Tamiflu is more effective at relieving flu symptoms than a combination of tamiflu and relenza

2010-11-03
In adults with seasonal influenza A virus infection, the combination of the drugs oseltamivir (tamiflu) and zanamivir (relenza) is less effective than oseltamivir monotherapy and not significantly more effective than zanamivir monotherapy. This key finding comes from a randomized, placebo-controlled trial— in adults presenting with influenza symptoms at general practices throughout France during the seasonal influenza epidemic in 2008-2009— carried out by Catherine Leport from the University of Paris, France, and colleagues, and reported in this week's PLoS Medicine. In ...

eHealth evaluation needs alternate approach

2010-11-03
In this week's PLoS Medicine Magazine, Trisha Greenhalgh and Jill Russell from the Queen Mary University of London discuss the relative merits of "scientific" and "social practice" approaches to evaluation and argue that eHealth evaluation is in need of a paradigm shift. They critique the previous PLoS Medicine series on evaluating eHealth, published in late 2009. INFORMATION:Funding: The ideas in this paper were developed during an independent evaluation of the UK Summary Care Record programme, funded by a research grant from the UK National Institute of Health Research ...

Doctors and drug companies are still too cozy

2010-11-03
David Henry discusses a recent research article in PLoS Medicine that suggests that relationships between doctors and drug companies are still too close. The research, by Geoffrey Spurling and colleagues, examined the relationship between exposure to promotional material from pharmaceutical companies and the quality, quantity, and cost of prescribing. David Henry's offers his Perspective in this week's PLoS Medicine Magazine. INFORMATION: Funding: The author received no specific funding for this article Competing Interests: The author has declared that no competing ...

Modify hospice eligibility for dementia patients, says Institute for Aging Research study

2010-11-03
BOSTON—The system for hospice admissions for patients with advanced dementia, which is a terminal illness, should be guided by patient and family preference for comfort, not estimated life expectancy, says a new study published in the Nov. 3 Journal of the American Medical Association by the Institute for Aging Research at Hebrew SeniorLife, an affiliate of Harvard Medical School. Currently, patients requesting hospice services must be certified by their physician to have six months or less to live, and must sign a statement choosing comfort care services in lieu of curative ...

Illnesses, injuries greatly increase chances of older adults developing new or worsening disability

2010-11-03
In a study examining the factors that play a role in an older adult's transition to disability, intervening illnesses and injuries that led to hospitalization or activity restriction were associated with worsening functional ability, especially among those who were physically frail, according to a study in the November 3 issue of JAMA, a theme issue on aging. Thomas M. Gill, M.D., of the Yale University School of Medicine, New Haven, Conn., presented the findings of the study at a JAMA media briefing at the National Press Club. Among older persons, disability in essential ...

Rate of falls in hospitals significantly reduced after use of intervention for fall prevention

2010-11-03
Use of a fall prevention tool kit, which included a fall risk assessment, patient-specific prevention plan, an educational handout and a poster for over the patient's hospital bed reduced the number of older patients with falls in hospitals, according to a study in the November 3 issue of JAMA, a theme issue on aging. Patricia C. Dykes, R.N., D.N.Sc., of Partners HealthCare System, Brigham and Women's Hospital and Harvard Medical School, Boston, presented the findings of the study at a JAMA media briefing at the National Press Club. "Falls are a public health problem ...

LAST 30 PRESS RELEASES:

MSU team develops scalable climate solutions for agricultural carbon markets

Playing an instrument may protect against cognitive aging

UNM study finds link between Grand Canyon landslide and Meteor Crater impact

Ultra-hot Jupiter’s death spiral could reveal stellar secrets

You only get one brain! The best helmet material for protecting your noggin

Neurodegeneration and stroke after GLP-1RAs in diabetes and obesity

Pediatric COVID-19 hospitalization trends by race and ethnicity, 2020-2023

Research spotlight: New genetic roadmap offers insights into obesity and diabetes

Fred Hutch leads new Vanguard Study for Cancer Screening Research Network

‘Mismatched’ transplants now safe, effective for blood cancer patients, study finds

New research helps narrow down uncertainties in near-term precipitation projections for the Asian Water Tower

AI tool accurately detects tumor location on breast MRI

Researchers use OCT imaging to uncover how the fallopian tube transports embryos

PolyU secures RGC theme-based research scheme funding to develop cost-effective and sustainable Co-GenAI model

Van Andel Institute scientists develop technique for high-resolution single cell epigenetic analysis

The Lundquist Institute wins multi-year NIH grant exceeding $11 million to transform diagnosis and treatment of deadly mucormycosis

Review suggests ending adult boosters for tetanus, diphtheria

ESMT Berlin welcomes Rebecca Schaumberg to faculty

Blocking a little-known protein may offer new hope for devastating lung disease

Medieval medicine was smarter than you think – and weirdly similar to TikTok trends

FAU receives NIH grant to investigate amphetamine addiction

Realizing on-site carbon nanotube photo-thermoelectric imaging

Most of us love memes. But are they a form of comics?

Novel biosensor allows real-time monitoring of sucrose uptake in plants

Korea University researchers reveal revealing how WEE1 drives cancer resistance to immunotherapy

Pusan National University researchers develop breakthrough deep learning model that enhances handheld 3D medical imaging

SLAS Discovery and SLAS Technology demonstrate research impact with 2024 impact factors

Disease-causing bacteria can deal with stink as long as they get a meal

Mapping the metabolism of blood stem cells

UK air quality improved since 2015 but targets still missed

[Press-News.org] Radically simple technique developed to grow conducting polymer thin films
Conductive plastic coatings could lead to new solar cells, windows, sensors