ONR's TechSolutions creating green ideas that light up ships and submarines

Solid State Lighting is 1 of several rapid-response technologies created using suggestions from Sailors and Marines

2011-02-28

(Press-News.org) ARLINGTON, Va. - One Sailor's request to replace humming fluorescent bulbs with a quiet alternative inspired the Office of Naval Research (ONR) to create the Solid State Lighting (SSL) project, currently being evaluated aboard several ships and submarines across the U.S. Navy.

A product of ONR's TechSolutions program, SSL is one of several rapid-response technologies created using recommendations and suggestions from Navy and Marine Corps personnel. (Watch TechSolutions products in action via YouTube.)

The SSL project introduced the energy-saving, nonhazardous LED fixtures on USS New Hampshire (SSN 778) in late January. In July, installation is also scheduled on USS New Mexico (SSN 779). These submarines will serve as pilot platforms to enable the Navy to measure savings achieved from SSL.

The new lighting fixtures are also being installed for testing on three surface ships: USS Pearl Harbor (LSD 52), USS Preble (DDG 88) and USS Chafee (DDG 90).

Although the SSL is in its early stages, the LED fixtures may one day replace existing hazardous fluorescent lights aboard submarines and surface ships. LEDs can reduce fuel use and maintenance requirements fleetwide and increase fleet readiness.

"LED lights are an immediate way to improve efficiency across the fleet," said Roger Buelow, chief technology officer at Energy Focus Inc. and principal investigator for the SSL project.

VIDEO: The Office of Naval Research's TechSolutions program works on ways to improve mission effectiveness through the application of technology. Solid State Lighting is one of several rapid-response technologies created using...
Click here for more information.

"Essentially, [SSL] lowers our workload and the amount of onboard spares that we are going to have to take on major deployments," said Chief Petty Officer Scott Brand, an electrician's mate on the New Hampshire. "That will significantly decrease the amount of space we have to consume with light bulbs."

LEDs contain no hazardous materials, unlike fluorescents, which must be stored on board until warfighters can perform expensive and intensive disposal procedures.

"The submarine community is pushing to adopt LEDs because fluorescents contain mercury," said Edward Markey, Naval Sea Systems Command (NAVSEA) Philadelphia Electrical Powergroup and TechSolutions technical point of contact on the SSL project. "Hazardous materials require special disposal procedures, costing the Navy time, money and space."

TechSolutions worked with Energy Focus to produce patented LED fixtures that are direct replacements for fluorescents. The replacements produce the same light output, but use half the power.

"As an example, the fluorescent version of the Berth light found in every Sailor's sleeping area runs at over 10 watts and is a legendary maintenance headache due to starter and lamp failures," Buelow said. "Because of TechSolutions, the fleet now has a qualified LED version that runs at five watts, delivers the same light output and will last for a decade without maintenance."

While Energy Focus fixtures have had a good track record on Navy ships, TechSolutions' products were the first to be fully qualified by the service. Those components met the most stringent electromagnetic interference standards, requiring innovative manufacturing methods. "Making any electrical appliance tough enough to pass Navy shock and vibration tests is a challenge," Buelow said.

The request to replace noisy fluorescent bunk lights with LEDs was submitted by a sonar technician at Commander, Submarine Force, Atlantic Fleet, Norfolk, Va. After realizing the potential, TechSolutions and NAVSEA decided to expand this effort beyond bunk lights to include all the T5 8W fluorescent fixtures in the forward habitability portion of the submarine.

INFORMATION:

TechSolutions works on ways to improve mission effectiveness through the application of technology. For more information about TechSolutions and to submit a request, Sailors and Marines can visit the Techsolutions website or e-mail ideas to techsolutions@onr.navy.mil.

About the Office of Naval Research

The Department of the Navy's Office of Naval Research (ONR) provides the science and technology necessary to maintain the Navy and Marine Corps' technological advantage. Through its affiliates, ONR is a leader in science and technology with engagement in 50 states, 70 countries, 1,035 institutions of higher learning and 914 industry partners. ONR employs approximately 1,400 people, comprising uniformed, civilian and contract personnel, with additional employees at the Naval Research Lab in Washington, D.C.

[Attachments] See images for this press release:

ELSE PRESS RELEASES FROM THIS DATE:

Making the 'irrelevant' relevant to understand memory and aging

2011-02-28

Age alters memory. But in what ways, and why? These questions comprise a vast puzzle for neurologists and psychologists. A new study looked at one puzzle piece: how older and younger adults encode and recall distracting, or irrelevant, information. The results, published in Psychological Science, a journal of the Association of Psychological Science, can help scientists better understand memory and aging. "Our world contains so much information; we don't always know which is relevant and which is irrelevant," said Nigel Gopie, who cowrote the study with Fergus I.M. Craik ...

Missing sugar molecule raises diabetes risk in humans

2011-02-28

Researchers at the University of California, San Diego School of Medicine and Rady Children’s Hospital-San Diego say an evolutionary gene mutation that occurred in humans millions of years ago and our subsequent inability to produce a specific kind of sialic acid molecule appears to make people more vulnerable to developing type 2 diabetes, especially if they’re overweight. The findings are published in the Feb. 24 online edition of The FASEB Journal, a publication of the Federation of American Societies of Experimental Biology. Corresponding study author, Jane ...

Examining climate change effects on wheat

2011-02-28

Wheat growers in the Southwest have a better idea about how to adjust to climate change in the decades ahead, thanks to U.S. Department of Agriculture (USDA) scientists in Arizona. Researchers with the USDA's Agricultural Research Service (ARS) installed infrared heaters in experimental wheat fields at the agency's Arid-Land Agricultural Research Center in Maricopa, Ariz., to simulate growing conditions expected by 2050. ARS is USDA's principal intramural scientific research agency, and this research supports the USDA priority of responding to climate change. Wheat ...

Rituximab and fludarabine produce long-term remissions in CLL

2011-02-28

COLUMBUS, Ohio – New research shows that a less-toxic combination of a targeted immune-based drug and a chemotherapy drug can produce long-term remissions in some chronic lymphocytic leukemia patients. And it does so without increasing the risk of later therapy-related myelodysplastic syndrome and acute myeloid leukemia, which can often occur with a three-drug combination used to treat these patients. The multi-institutional study, led by researchers at the Ohio State University Comprehensive Cancer Center – Arthur G. James Cancer Hospital and Richard J. Solove Research ...

Genetically modified fungi kill malaria-causing parasites in mosquitoes

2011-02-28

Spraying malaria-transmitting mosquitoes with a genetically modified fungus can kill the malaria parasite without harming the mosquito, potentially reducing malaria transmission to humans, according to a new study published in the journal Science. Funded by the National Institute of Allergy and Infectious Diseases (NIAID), part of the National Institutes of Health, the study was led by Raymond J. St. Leger, Ph.D., of the University of Maryland, College Park. An estimated 225 million malaria cases occur worldwide annually, resulting in about 781,000 deaths each year, ...

Drier conditions projected to accelerate dust storms in the southwest

2011-02-28

MOAB, Utah — Drier conditions projected to result from climate change in the Southwest will likely reduce perennial vegetation cover and result in increased dust storm activity in the future, according to a new study by scientists with the U.S. Geological Survey and the University of California, Los Angeles. The research team examined climate, vegetation and soil measurements collected over a 20-year period in Arches and Canyonlands National Parks in southeastern Utah. Long-term data indicated that perennial vegetation in grasslands and some shrublands declined with temperature ...

GSA Bulletin highlights: New research posted Feb. 4-11, 2011

2011-02-28

Boulder, CO, USA - GSA BULLETIN is now posting pre-issue publication content -- finalized papers that are ready to go to press and not under embargo. GSA invites you to sign up for e-alerts and be the first to have access to new journal content as it becomes available. Sign in at http://www.gsapubs.org/cgi/alerts with your e-mail address to manage subscriptions for pre-issue postings, full tables of contents alerts, and more. Keywords: Silicic calderas, Quaternary, Iberian Peninsula, Tsuboi's technique, Colorado River, Gran Desierto dune field, ASTER. Eel River, LiDAR, ...

Viral infection not responsible for exacerbation of lung disease in most patients

2011-02-28

Acute viral infection does not appear to be a primary cause of acute exacerbation of idiopathic pulmonary fibrosis (IPF), a progressive, deadly disease resulting in thickening and scarring of the lungs, according to a study conducted by researchers from the U.S., Korea and Japan. Previous studies had suggested viral infection might cause exacerbation of IPF in a majority of patients who have the condition, which occurs most often in people between 50 and 70 years of age. The findings were published online ahead of the print edition of the American Thoracic Society's American ...

New kind of optical fiber developed

2011-02-28

A team of scientists led by John Badding, a professor of chemistry at Penn State University, has developed the very first optical fiber made with a core of zinc selenide -- a light-yellow compound that can be used as a semiconductor. The new class of optical fiber, which allows for a more effective and liberal manipulation of light, promises to open the door to more versatile laser-radar technology. Such technology could be applied to the development of improved surgical and medical lasers, better countermeasure lasers used by the military, and superior environment-sensing ...

New way to identify patients at risk of dysphagia after head and neck cancer treatment

2011-02-28

At the 3rd International Conference on innovative approaches in Head and Neck Oncology (ICHNO), Dr Hanna Rahbek Mortensen and colleagues at hospitals and institutes in Denmark presented results from a large prospective trial, the DAHANCA 6 & 7 study. The study, conducted across the country, investigated risk factors for developing dysphagia (swallowing dysfunction), after undergoing radiotherapy treatment for a head & neck cancer. "We followed 1,476 patients with squamous cell carcinoma of the head and neck and found out the existence of factors related to the cancer itself, ...

ONR's TechSolutions creating green ideas that light up ships and submarines

ELSE PRESS RELEASES FROM THIS DATE:

LAST 30 PRESS RELEASES: