(Press-News.org) Getting two fluids to mix in small or confined spaces is a big problem in many industries where, for instance, the introduction of one fluid can help extract another — like water pumped underground can release oil trapped in porous rock — or where the mixing of liquids is the essential point of the process. A key example of the latter is microfluidics technology, which allows for the controlled manipulation of fluids in miniscule channels often only a few hundred nanometers wide.
Microfluidic devices were first introduced in the 1980s and for many years were best known for their use in ink-jet printers, but have since been introduced in other fields, including the chemical analysis of blood or other sera in lab-on-a-chip technologies. These devices — usually not much larger than a stick of chewing gum — sometimes rely on nano-sized moving components, the geometry of the grooved channels or pulsed injections to induce a mixing of the fluids. But researchers in MIT's Department of Civil and Environmental Engineering suggest that a simpler method might be equally, if not more, effective.
"Getting two fluids to mix in a very tight space is difficult because there's not much room for a disorderly flow," said Professor Ruben Juanes, the ARCO Associate Professor in Energy Studies and principal investigator on the research. "But with two fluids of highly contrasting viscosity, the thinner fluid naturally creates disorder, which proves to be a marvelously efficient means of mixing."
In an analysis published online May 12 in Physical Review Letters (PRL), the researchers show that the injection of a thin or low-viscosity fluid into a much more viscous fluid (think of water spurting into molasses) will cause the two fluids to mix very quickly via a physical process known as viscous fingering. The thinner liquid, say the researchers, will form fingers as it enters the thicker liquid, and those fingers will form other fingers, and so on until the two liquids have mixed uniformly.
They also found that for maximum mixing to occur quickly, the ideal ratio of the viscosity of any two fluids depends on the speed at which the thinner liquid is injected into the thicker one.
The research team of Juanes, postdoctoral associate Luis Cueto-Felgueroso and graduate students Birendra Jha and Michael Szulczewski, made a series of controlled experiments using mixtures of water and glycerol, a colorless liquid generally about a thousand times more viscous than water. By alternating the viscosity of the liquids and the velocity of the injection flows, Jha was able to create a mathematical model of the process and use that to determine the best viscosity ratio for a particular velocity. He is lead author on the PRL paper.
"It's been known for a very long time that a low viscosity fluid will finger through the high viscosity fluid," said Juanes. "What was not known is how this affects the mixing rate of the two fluids. For instance, in the petroleum industry, people have developed increasingly refined models of how quickly the low viscosity fluid will reach the production well, but know little about how it will mix once it makes contact with the oil."
Similarly, Juanes said, in microfluidics technology, the use of fluids of different viscosities has not been seriously proposed as a mixing mechanism, but the new study indicates it could work very efficiently in the miniscule channels.
"We can now say that on average, the viscosity of the fluid injected should be about 10 times lower than that of the fluid into which it is injected," said Juanes. "If the contrast is greater than 10, then the injection should be done more slowly to achieve the fastest maximum mixing. Otherwise, the low viscosity fluid will create a single channel through the thicker fluid, which is not ideal."
Cueto-Felgueroso said a similar process is at work in the engraved channels of a microfluidic device and in subsurface rock containing oil. "Mixing fluids at small scales or velocities is difficult because you can't rely on turbulence: it would be hard to stir milk into your coffee if you were using a microscopic cup," Cueto-Felgueroso said. "With viscous fingering, you let the fluids do the job of stirring."
###
Movie 1: http://www.youtube.com/watch?v=NZEB8tQ3eOM
Movie 2: http://www.youtube.com/watch?v=baqWMeKTAkU
Plants can overcome their evolutionary legacies to become much better at using biological photosynthesis to produce energy, the kind of energy that can power vehicles in the near future, an all-star collection of biologists, physicists, photochemists, and solar scientists has found.
A U.S. Department of Energy (DOE) workshop that drew a prestigious collection of 18 scientists to compare the efficiency of plants and photovoltaic solar cells led to an important and provocative scholarly article in today's issue of the journal Science. Two of the scientists are from DOE's ...
Films depicting the 1787 mutiny aboard the British ship HMS Bounty show sailors living cheek by jowl, being forced to dance, enduring storm-ridden Cape of Good Hope crossings to satisfy the ship captain's ego and being flogged for trivial reasons.
We may not think that these harsh conditions have much relevance today. But mutinies continue to occur, especially in the armed forces of developing nations. And mutinies have similarities to other types of rebellions, including worker strikes, riots, prison rebellions and political uprisings.
University of Washington sociologists ...
EAST LANSING, Mich. — In a head-to-head battle of harvesting the sun's energy, solar cells beat plants, according to a new paper in Science. But scientists think they can even up the playing field, says researcher David Kramer at Michigan State University.
Plants are less efficient at capturing the energy in sunlight than solar cells mostly because they have too much evolutionary baggage. Plants have to power a living thing, whereas solar cells only have to send electricity down a wire. This is a big difference because if photosynthesis makes a mistake, it makes toxic ...
Since 2008, the U.S. economy has been "seizing" uncontrollably. Now a Tel Aviv University researcher says that a comparison of the multifaceted economic downturn with the uncontrolled spasms of an epileptic is not inappropriate — and may say something about the origins of the disaster.
In a recent article published in the journal PLoS ONE, Prof. Eshel Ben-Jacob of Tel Aviv University's School of Physics and Astronomy, his doctoral student Dror Y. Kenett and economist Dr. Gitit Gur-Gershgorn examined the dynamics of the S&P 500 over the last decade, employing methods originally ...
The Wildlife Conservation Society and other organizations released a new study recommending a disease screening program for farm-raised caiman in ranching facilities in Argentina to ensure the safety of people and wildlife alike.
The recommendations focus on two crocodilian species, the yacare caiman and broad-snouted caiman, both of which are reared in caiman ranches for sustainable harvest. The research team sought to assess the presence of potentially harmful bacteria in captive-raised caiman at a typical ranching facility in Argentina's Chaco region, where several ...
Vidaroo Corporation today announced that it has contracted with Emmis Radio, a subsidiary of Emmis Communications Corporation, for use of its video distribution and syndication platform for Emmis' 22 radio stations.
Vidaroo's Enterprise software will allow Emmis' radio stations to deliver its website's video distribution through use of Vidaroo's centralized management platform, as well as distribute live and on-demand content and branded time-of-day programming. In addition to use of the Vidaroo platform for video distribution and syndication, Emmis will also be able ...
The following highlights summarize research papers that have been recently published in Geophysical Research Letters (GRL), Water Resources Research (WRR), the Journal of Geophysical Research-Oceans (JGR-C), and the Journal of Geophysical Research-Solid Earth (JGR-B).
In this release:
New freshwater source for Antarctic coastal waters
Phytoplankton affect clouds and precipitation
River model enhanced by floodplain dynamics
Weighing natural variability in projected precipitation change
Study suggests no slowing of Atlantic 'conveyor belt' current
Warming, salinity ...
Contour, Inc is a market leader in wearable video technology, introducing innovative new features such as integrated GPS tracking and bluetooth connectivity to smartphone devices. Contour have just announced the release of their latest product, the Contour+ camera. The Contour+ builds on the popular Contour GPS model with added connectivity and refined features and has been designed with the broadcast and pro-sumer market in mind.
Contour cameras are renowned for their ease of use thanks to the large sliding start/stop switch on top of the camera and their unique rotating ...
If pending clinical trials prove successful, a new discovery published in The FASEB Journal (http://www.fasebj.org) could represent a major scientific leap toward human tissue regeneration and engineering. In a research report appearing online, Yale scientists provide evidence to support a major paradigm shift in this specialty area from the idea that cells added to a graft before implantation are the building blocks of tissue, to a new belief that engineered tissue constructs can actually induce or augment the body's own reparative mechanisms, including complex tissue ...
CHAMPAIGN, Ill. — Researchers tracking the spread of Toxoplasma gondii – a parasite that reproduces only in cats but sickens and kills many other animals – have found infected wildlife throughout a 1,500-acre (600-hectare) natural area in central Illinois.
The researchers also found dozens of free-ranging cats in the area, the Robert Allerton Park, near Monticello, Ill. Two years of tracking, trapping and motion-triggered night photography at eight sites in the park found no evidence of bobcats, but plenty of examples of feral or abandoned house cats, many of them infected ...
