(Press-News.org)
Climate change, expedited by anthropogenic activities, has become a major environmental concern in this century. Governments and organizations worldwide are gradually making substantial efforts to mitigate this challenge. A concrete step in this direction is to develop novel technologies that capture and convert low-concentration carbon dioxide into useful products. Recently, scientists have proposed carbon dioxide methanation in a membrane reactor as a promising approach. Specifically, distribution-type membrane reactors are appealing owing to high catalyst activity through hotspot formation mitigation.
Although the effectiveness of membrane reactors has been confirmed, the efficiency of membrane properties and heat transfer characteristics of membrane materials remain unclear.
In a new study, a team of researchers led by Professor Mikihiro Nomura from Shibaura Institute of Technology, Japan, and including Yuka Shimizu from the same institute and Marcin Moździerz, Grzegorz Brus, and Elzbieta Fornalik-Wajs from AGH University of Krakow, Poland, has demonstrated the novelty of distribution-type membrane reactor for carbon dioxide utilization. Their findings were made available online on 17 September 2025 and have been published in Volume 462 of the journal Catalysis Today on 1 February 2026.
“Through a double degree program between Shibaura Institute of Technology and AGH University of Krakow, we evaluated heat transfer in membrane components, which enabled us to demonstrate the specific advantages of the membrane reactors addressed in our research,” explains Prof. Nomura.
Following this, the team controlled the reaction rate inside the reactor by distributed reactant feeding through the membrane. They subsequently conducted accurate thermal conductivity evaluation of the porous alumina (Al2O3) membrane with minute physical and chemical structural features via laser flash analysis measurements. The thermal conductivity in the solid part of this sample was measured to be 36.4% lower than that of non-porous alumina.
The researchers then utilized a catalytic membrane with a silica separation layer—with a hydrogen gas permeance of 1.4 × 10⁻⁶ mol m−2 s−1 Pa−1 and a hydrogen-to-carbon dioxide selectivity of 35.9—in the distributor-type membrane reactor test. They obtained a high carbon dioxide conversion of 92.3% at 350 ℃.
Built on these results, the team carried out Ansys Fluent software-based simulations to examine the impact of membrane thermal conductivity and permselectivity. The team set carbon dioxide permeance of the membrane to 3.91 × 10−8 mol m−2 s−1 Pa−1 for all situations, finding that the carbon dioxide permselective membrane with a high selectivity of 35.9 produces about 1.4 times more methane than the hydrogen permselective membrane with a low selectivity of 0.10. Furthermore, higher thermal conductivity of the membrane suppresses the temperature rise in the reactor.
“Membrane reactors enable spatially distributed reactant feeding within the reactor, providing enhanced control over reaction rates and temperature profiles in both the axial (flow) and the radial (membrane surface) directions. This unique capability and membrane shape make them well-suited for application in small-scale facilities. Therefore, applying membrane reactors to small-scale carbon dioxide emission sources—which are commonly owned by many small- and medium-sized enterprises with limited funding—will accelerate the realization of a carbon-neutral society. In particular, we anticipate their use in small combustion devices such as boilers, an area that has received little attention in efforts to combat global warming,” concludes Prof. Nomura.
These results can also guide other exothermic processes such as hydrocarbon partial oxidation in membrane reactor systems, boosting sustainable technologies.
***
Reference
DOI: 10.1016/j.cattod.2025.115569
About Shibaura Institute of Technology (SIT), Japan
Shibaura Institute of Technology (SIT) is a private university with campuses in Tokyo and Saitama. Since the establishment of its predecessor, Tokyo Higher School of Industry and Commerce, in 1927, it has maintained “learning through practice” as its philosophy in the education of engineers. SIT was the only private science and engineering university selected for the Top Global University Project sponsored by the Ministry of Education, Culture, Sports, Science and Technology and had received support from the ministry for 10 years starting from the 2014 academic year. Its motto, “Nurturing engineers who learn from society and contribute to society,” reflects its mission of fostering scientists and engineers who can contribute to the sustainable growth of the world by exposing their over 9,500 students to culturally diverse environments, where they learn to cope, collaborate, and relate with fellow students from around the world.
Website: https://www.shibaura-it.ac.jp/en/
About Professor Mikihiro Nomura from SIT, Japan
Professor Mikihiro Nomura leads the Separation Systems Engineering Laboratory at Shibaura Institute of Technology, Japan. With a focus on ceramic membrane separation technology, Prof. Nomura aims to advance efficient separation processes for hydrogen, carbon dioxide, and wastewater, contributing to the realization of a carbon-neutral society. Through innovative approaches and a commitment to sustainability, he and his team strive to address pressing environmental challenges with cutting-edge engineering solutions.
END
In rapidly growing cities like Tokyo, incorporating greenery is a challenging task. With limited space for trees or parks, vertical greening—the placement of vegetation on building façades—has become a creative solution to reintroduce nature into crowded urban settings. However, until now, there has been no clear method to assess where this type of greenery is most needed or most effective.
To address this challenge, researchers from Chiba University in Japan have created a data-driven spatial framework that identifies the best locations for vertical greening throughout Tokyo's 23 wards. The study, ...
People with cancer who received diabetes care from clinical pharmacists achieved significantly better blood sugar control, according to new research from the University of California San Diego. The study, published in Diabetes Spectrum on Oct. 30, 2025 found that patients referred to a diabetes management and education clinic led by pharmacists saw meaningful improvements in blood sugar levels over time, underscoring the critical role pharmacists can play in supporting this high-risk group.
“Cancer and hyperglycemia can be a harmful combination,” said Christina Mnatzaganian, Pharm.D., health sciences clinical professor at UC San Diego Skaggs School of Pharmacy and Pharmaceutical ...
A child’s early gut microbiome may influence their risk of developing depression, anxiety or other internalizing symptoms in middle childhood, according to a new UCLA Health study. The effect appears to be related to the way bacteria are linked to communication across emotion-related brain networks.
Published in the journal Nature Communications, the observational study found that young children whose gut microbiome had higher representation of bacteria in the Clostridiales order and Lachnospiraceae family were at higher risk of experiencing ...
Scientists have long sought to make semiconductors—vital components in computer chips and solar cells—that are also superconducting, thereby enhancing their speed and energy efficiency and enabling new quantum technologies. However, achieving superconductivity in semiconductor materials such as silicon and germanium has proved challenging due to difficulty in maintaining an optimal atomic structure with the desired conduction behavior.
In a newly published paper in the journal Nature Nanotechnology, ...
UNIVERSITY PARK, Pa. — Obesity is a global epidemic affecting millions of people every day and is associated with comorbidities ranging from heart disease and Type 2 diabetes to osteoarthritis and social stigma. While lifestyle factors, like diet and exercise, affect obesity, years of genetic research have identified about 20 genes that have a high effect on the likelihood of a person developing the condition.
Now, a new study published today (Oct. 30) in Nature Communications, by researchers at Penn State, involving about 850,000 adults ...
One of the most common antidepressants, sertraline, contributes to a modest improvement in core depression and anxiety symptoms, including low mood, within two weeks, finds a new analysis of a major clinical trial led by UCL researchers.
The study, published in Nature Mental Health, analysed the findings of the PANDA trial, which first published results in 2019 and found that sertraline may have an earlier impact on anxiety than depressive symptoms.* Researchers have now conducted a network analysis of the results, which is an innovative statistical method that allowed them to explore how specific symptoms respond to treatment.
The ...
Scientists have paved the way for next-generation quantum circuits by successfully making a semiconducting element commonly used in electrical devices superconducting.
A research team from The University of Queensland’s School of Mathematics and Physics and Australian Institute for Bioengineering and Nanotechnology and New York University have shown germanium can conduct electricity without resistance.
The discovery, which had eluded physicists for more than 60 years, unifies the building blocks of classical electronics and quantum ...
Australian researchers have created tiny compartments to help supercharge photosynthesis, potentially boosting wheat and rice yields while slashing water and nitrogen use.
Researchers from Associate Professor Yu Heng Lau’s group at the University of Sydney and Professor Spencer Whitney’s group at Australian National University have spent five years tackling a fundamental problem: how can we make plants fix carbon more efficiently?
The team engineered nanoscale ‘offices' that can ...
New research has found that microbial communities in soil have the capacity to remember and adapt to past environmental events, helping plants to withstand drought stress.
Experts from the University of Nottingham's School of Biosciences in collaboration with scientists from the University of Kansas found that soil microbes carry a long-term memory of past climate, and that this memory can shape how some plants respond to new droughts. The findings have been published today in Nature Microbiology.
Droughts ...
URBANA, Ill. — Airplane travel is more popular than ever, and our desire for fast transportation means jet fuel has become a major contributor to greenhouse gas emissions. Now, researchers at the University of Illinois Urbana-Champaign have discovered a novel way to address that problem—by converting food waste into sustainable aviation fuel (SAF) that meets industry standards without relying on fossil fuel blends. Their process, described in a new Nature Communications study, could help the aviation industry meet its ambitious ...
