PRESS-NEWS.org - Press Release Distribution
PRESS RELEASES DISTRIBUTION

Using recycled cardboard in food packaging risks contaminating food with mineral oils

Harmful mineral oils from the printing inks used on cardboard can migrate into food if recycled cardboard is used for food packaging

2011-06-16
(Press-News.org) Harmful mineral oils from the printing inks used on cardboard can migrate into food if recycled cardboard is used for food packaging. It may contaminate food even if the recycled cardboard is used for the corrugated card transport box that holds individual packs. In tests on experimental packs of fine noodles, researchers in Zurich, Switzerland, found that food rapidly absorbed 10 times the recommended limit for concentration of these contaminating oils from the transport box. The findings were published in the latest edition of Packaging Technology and Science.

The world-recognised limit for these oils is 0.6mg in each kg of food, but researchers discovered that after standing in packaging for just six weeks, food could contain 6.1mg/kg. And this was in food that had a two-year shelf life, so it is quite possible the value could increase further over time.

Many dry foods such as rice, noodles, breadcrumbs, cornflakes and muesli are sold in paperboard boxes, where the recommended limit may be exceeded over 100 times. Even more foods are stored and transported in larger boxes largely consisting of recycled paperboard. The research showed that even if the food was contained in clean paperboard boxes from fresh fibres, printed with inks free of mineral oil and wrapped into a polyethylene film (also free of mineral oil); mineral oils from the corrugated card transport box far exceeded the limit.

"There is a tension between the need to recycle paper and board and the need to keep food free from high levels of these mineral oils," says Dr. Koni Grob, an analytical chemist who headed the research team based at the Official Food Control and points out that none of the three presently discussed solutions are easy to put into practice.

The first approach could be to use paperboard made by recycling carefully selected, cleaner starting materials. But when the team ran tests using board with a mineral oil concentration approximately 5 times lower than usual (apparently the best feasible), the mineral oil migration into the food still exceeded the limit about 7 times. "It is unlikely that the target can be reached by this approach," says Grob.

Secondly, manufacturers could use new wood fibres when making food packaging and transport boxes. "This change would be difficult for two reasons. Firstly you can't work fresh fibres on the same machines you use for recycled fibres, and at the moment there is no machinery to produce the enormous extra amounts of fresh fibre paperboard required to replace the recycled board. Secondly, it would trigger a massive increase in the demand for wood to supply them. All the wood growing in Switzerland would not be sufficient to supply Europe with the extra amount needed - and Switzerland is well covered by forests," says Dr. Grob.

Thirdly, manufactures could introduce functional barriers against the migration of mineral oil, either as internal bags or lining the boxes with materials such as special plastics. This might be the way to go, but the technology is not ready and the recyclability of lined paperboard needs to be tested.

Many companies have realised the problem and recently some have changed their packaging materials to fresh fibre paperboard printed with inks free of mineral oil. "But they are still using recycled card in the corrugated board transport boxes which renders their efforts fruitless," says Dr. Grob. "In terms of amounts of food packaging material involved, this problem exceeds all those experienced in the past. It needs to be addressed with corresponding care."

INFORMATION:

This study is published in the journal Packaging Technology & Science. Media wishing to receive a PDF of this article may contact physicalsciencenews@wiley.com.

Full Citation

"Migration of mineral oil into noodles from recycled fibers in the paperboard box and the corrugated board transport box as well as from printing inks: a case study" Maurus Biedermann, Jan-Erik Ingenhoff, Martino Barbanera, Davide Garbini and Koni Grob. Packaging Technology and Science; 2011 DOI: 10.1002/pts.937 The URL upon publication will be http://onlinelibrary.wiley.com/doi/10.1002/pts.937/pdf.

About the Journal

Packaging Technology & Science is a scientific peer review journal that provides an international forum for the publication of research papers and review articles about developments in this field. As such, it is aimed at packaging engineers and technologists, food scientists and technologists, polymer scientists, toxicologists, analytical chemists, environmental scientists, materials scientists, regulatory officers, and other professionals who are concerned with the development and applications of packaging, as well as its effects. For more information, please visit http://onlinelibrary.wiley.com/journal/10.1002/%28ISSN%291099-1522

About Wiley

Founded in 1807, John Wiley & Sons, Inc., has been a valued source of information and understanding for more than 200 years, helping people around the world meet their needs and fulfill their aspirations. Since 1901, Wiley and its acquired companies have published the works of more than 450 Nobel laureates in all categories: Literature, Economics, Physiology/Medicine, Physics, Chemistry and Peace.

Wiley's core businesses include scientific, technical, medical and scholarly (STMS) journals, encyclopedias, books and online products and services; professional/trade books, subscription products, training materials, online applications and Web sites; and educational materials for undergraduate and graduate students and lifelong learners. Wiley's global headquarters are located in Hoboken, N.J., with operations in the U.S., Europe, Asia, Canada and Australia. The company's Web site can be accessed at www.wiley.com. The company is listed on the New York Stock Exchange under the symbols JWa and JWb.

END



ELSE PRESS RELEASES FROM THIS DATE:

Fort Worth Family Restaurant Swarmed by Angry Birds

Fort Worth Family Restaurant Swarmed by Angry Birds
2011-06-16
The Eatery on Beach Street in Fort Worth now features iPads with the popular game Angry Birds to entertain children while Chef Don Gifford prepares homestyle meals from scratch. "Young ones can help the Angry Birds get revenge for stolen eggs on The Eatery's iPads while I make their favorites from our new dinner menu," said Chef Don Gifford. "Our made-from-scratch gourmet Mac and Cheese bar has been bringing lots of families with children to The Eatery on Thursday nights, and the kids light up when they see the iPads," said Cindy Gifford. The ...

NIH researchers identify new marker to predict progressive kidney failure, death

2011-06-16
A high level of a hormone that regulates phosphate is associated with an increased risk of kidney failure and death among chronic kidney disease (CKD) patients, according to a recent study led by researchers at the University of Miami and funded by the National Institute of Diabetes and Digestive Diseases and Kidney Diseases (NIDDK) at the National Institutes of Health. Results are in the June 15 issue of the Journal of the American Medical Association. In a previous study of patients beginning hemodialysis for treatment of kidney failure, individuals with elevated blood ...

Rutgers contributes to findings that black holes were surprisingly common in early universe

2011-06-16
NEW BRUNSWICK, N.J. – A Rutgers University astrophysicist is part of a scientific team that has unveiled evidence of black holes being common in the early universe. The discovery, made using NASA's Chandra X-ray Observatory, shows that these young black holes grew more aggressively than scientists previously thought. The finding has important implications for how astronomers understand the early cosmos, according to Eric Gawiser, assistant professor in Rutgers' Department of Physics and Astronomy, School of Arts and Sciences. "There is a deep and mysterious connection ...

Study reveals important aspects of signaling across cell membranes in plants

Study reveals important aspects of signaling across cell membranes in plants
2011-06-16
Every living plant cell and animal cell is surrounded by a membrane that helps it communicate with other cells and the outside world. These cellular membranes contain receptor molecules that serve as the cell's eyes and ears. The receptor molecules accomplish three basic things in the communication process: 1) recognize an outside signal, 2) transport that signal across the cell's membrane and 3) initiate the reading of the signal inside the cell and then initiate the cell's response to that signal. These steps are collectively known as transmembrane signaling. Transmembrane ...

Scientists prove existence of 'magnetic ropes' that cause solar storms

2011-06-16
FAIRFAX, Va., June 15, 2011—George Mason University scientists discovered recently that a phenomenon called a giant magnetic rope is the cause of solar storms. Confirming the existence of this formation is a key first step in helping to mitigate the adverse effects that solar storm eruptions can have on satellite communications on Earth. The discovery was made by associate professor Jie Zhang and his graduate student Xin Cheng using images from the NASA Solar Dynamic Observatory (SDO) spacecraft. Though the magnetic rope was believed to be the cause of these giant ...

Study: MR enterography as effective as CT in diagnosing Crohn's disease, reduces radiation exposure

2011-06-16
MR enterography reduces exposure to ionizing radiation Revising protocol may reduce costs, complexity while maintaining integrity of diagnosis Use of anti-peristalitc agent may not be necessary to obtain high-quality images (Providence, R.I.) – A new study from Rhode Island Hospital has found that MR enterography (MRE) without the use of an anti-peristaltic agent were as reliable as CT enterography (CTE) in determining the presence of Crohn's disease. Additionally, MRE reduces the patient's exposure to ionizing radiation. The study is now published online in advance ...

Fathers benefit from seeking help as parents

2011-06-16
Men are sometimes criticized for being unwilling to ask for directions when they travel, but they can benefit from looking for help as they begin their journeys as fathers, according to a researcher on fatherhood at the University of Chicago. Along the way, they should not shy from asserting their roles, said Jennifer Bellamy, an Assistant Professor at the University of Chicago School of Social Service Administration. "Sometimes dads feel like they don't get the same level of support that moms do when they become parents, but I think dads should seek opportunities from ...

Study hints at antibiotic overuse in home-care patients

2011-06-16
CHICAGO (June 15, 2011) – A study of Canadian home-care patients suggests doctors may be overprescribing antibiotics for patients receiving ongoing medical care at home. The study, published in the June issue of Infection Control and Hospital Epidemiology, the journal of the Society for Healthcare Epidemiology of America, suggests that more should be done to monitor antibiotic use in home-care patients to avoid misuse that could decrease the efficacy of the drugs over time. According to the study, led by researchers from McMaster University in Ontario, antibiotic prescriptions ...

'Glowing hands' in the waiting room improves kids' handwashing

2011-06-16
CHICAGO (June 15, 2011) – Use of a glowing gel that shows kids how well they wash their hands by illustrating bacteria they missed while washing and may significantly improve hand hygiene, according to a study published in the July issue of Infection Control and Hospital Epidemiology, the journal of the Society for Healthcare Epidemiology of America. What makes this particular intervention unique is where it was performed: a children's hospital emergency department waiting room. "Waiting for the doctor is usually a tiresome and unproductive experience, but we were able ...

Potential cause of severe sleep disorder discovered, implications for Parkinson's disease

2011-06-16
TORONTO, ON – Researchers at the University of Toronto are the first to indentify a potential cause for a severe sleep disorder that has been closely linked to Parkinson's disease and other neurodegenerative diseases. "Our research is the first to establish a potential genetic link to human REM sleep behaviour disorder (RBD). That's important because between 60 and 80 per cent of people diagnosed with human RBD develop Parkinson's disease or other neurodegenerative disorders later in life," says Dr. John Peever, lead author of the study that recently appeared in The Journal ...

LAST 30 PRESS RELEASES:

Plant doctor: An AI system that watches over urban trees without touching a leaf

Study tracks chromium chemistry in irradiated molten salts

Scientists: the beautiful game is a silver bullet for global health

Being physically active, even just a couple of days a week, may be key to better health

High-fat diet promote breast cancer metastasis in animal models

A router for photons

Nurses and AI collaborate to save lives, reduce hospital stays

Multi-resistance in bacteria predicted by AI model

Tinker Tots: A citizen science project to explore ethical dilemmas in embryo selection

Sensing sickness

Cost to build multifamily housing in California more than twice as high as in Texas

Program takes aim at drinking, unsafe sex, and sexual assault on college campuses

Inability to pay for healthcare reaches record high in U.S.

Science ‘storytelling’ urgently needed amid climate and biodiversity crisis

KAIST Develops Retinal Therapy to Restore Lost Vision​

Adipocyte-hepatocyte signaling mechanism uncovered in endoplasmic reticulum stress response

Mammals were adapting from life in the trees to living on the ground before dinosaur-killing asteroid

Low LDL cholesterol levels linked to reduced risk of dementia

Thickening of the eye’s retina associated with greater risk and severity of postoperative delirium in older patients

Almost one in ten people surveyed report having been harmed by the NHS in the last three years

Enhancing light control with complex frequency excitations

New research finds novel drug target for acute myeloid leukemia, bringing hope for cancer patients

New insight into factors associated with a common disease among dogs and humans

Illuminating single atoms for sustainable propylene production

New study finds Rocky Mountain snow contamination

Study examines lactation in critically ill patients

UVA Engineering Dean Jennifer West earns AIMBE’s 2025 Pierre Galletti Award

Doubling down on metasurfaces

New Cedars-Sinai study shows how specialized diet can improve gut disorders

Making moves and hitting the breaks: Owl journeys surprise researchers in western Montana

[Press-News.org] Using recycled cardboard in food packaging risks contaminating food with mineral oils
Harmful mineral oils from the printing inks used on cardboard can migrate into food if recycled cardboard is used for food packaging