PRESS-NEWS.org - Press Release Distribution
PRESS RELEASES DISTRIBUTION

Team uses forest waste to develop cheaper, greener supercapacitors

2013-10-24
(Press-News.org) Contact information: Diana Yates
diya@illinois.edu
217-333-5802
University of Illinois at Urbana-Champaign
Team uses forest waste to develop cheaper, greener supercapacitors

CHAMPAIGN, Ill. — Researchers report that wood-biochar supercapacitors can produce as much power as today's activated-carbon supercapacitors at a fraction of the cost – and with environmentally friendly byproducts.

The report appears in the journal Electrochimica Acta.

"Supercapacitors are power devices very similar to our batteries," said study leader Junhua Jiang, a senior research engineer at the Illinois Sustainable Technology Center at the University of Illinois. While batteries rely on chemical reactions to produce sustained electrical energy, supercapacitors collect charged ions on their electrodes (in this case, the biochar), and quickly release those ions during discharge. This allows them to supply energy in short, powerful bursts – during a camera flash, for example, or in response to peak demand on the energy grid, Jiang said.

"Supercapacitors are ideal for applications needing instant power and can even provide constant power – like batteries, but at lower cost," he said. They are useful in transportation, electronics and solar- and wind-power energy storage and distribution.

Many of today's supercapacitors use activated carbon – usually from a fossil-fuel source, Jiang said.

"Costly and complicated procedures are normally used to develop the microstructures of the carbon – to increase the number of pores and optimize the pore network," he said. "This increases the surface area of the electrode and the pores' ability to rapidly capture and release the ions."

In wood-biochar supercapacitors, the wood's natural pore structure serves as the electrode surface, eliminating the need for advanced techniques to fabricate an elaborate pore structure. Wood biochar is produced by heating wood in low oxygen.

The pore sizes and configurations in some woods are ideal for fast ion transport, Jiang said. The new study used red cedar, but several other woods such as maple and cherry also work well.

Expensive and corrosive chemicals are often used to prepare the activated carbon used in supercapacitors, giving the electrodes the physical and chemical properties they need to function well, Jiang said.

"The use of those chemicals will probably impose some environmental impacts," he said. "This should be avoided or at least substantially reduced."

Jiang and his team activated their biochar with mild nitric acid, which washed away the ash (calcium carbonate, potassium carbonate and other impurities) in the biochar. The byproduct of this process has a beneficial use, Jiang said: The resulting solution of nitrate compounds can be used as fertilizer.

These simple approaches dramatically cut the material and environmental costs of assembling supercapacitors.

"The material costs of producing wood-biochar supercapacitors are five to 10 times lower than those associated with activated carbon," Jiang said. And when a biochar supercapacitor has reached the end of its useful life, the electrodes can be crushed and used as an organic soil amendment that increases fertility.

"The performance of our biochar materials is comparable to the performance of today's advanced carbon materials, including carbon nanotubes and graphenes," Jiang said. "We can achieve comparable performance with much less cost and probably much lower environmental costs."



INFORMATION:

The Illinois Hazardous Waste Research Fund and the HeteroFoaM Center (an Energy Frontier Research Center funded by the U.S. Department of Energy's Office of Basic Research) supported this study (award #DESC0001061).

The Illinois Sustainability Technology Center is part of the Prairie Research Institute at the U. of I.

Editor's notes: To reach Junhua Jiang, email junhua@illinois.edu.

The paper, "Highly Ordered Macroporous Woody Biochar With Ultra-High Carbon Content as Supercapacitor Electrodes," is available online or from the U. of I. News Bureau.



ELSE PRESS RELEASES FROM THIS DATE:

UNC child neurologist finds potential route to better treatments for Fragile X, autism

2013-10-24
UNC child neurologist finds potential route to better treatments for Fragile X, autism CHAPEL HILL, N.C. – When you experience something, neurons in the brain send chemical signals called neurotransmitters across synapses to receptors on ...

Coral chemicals protect against warming oceans

2013-10-24
Coral chemicals protect against warming oceans Nature paper reveals coral animals produce the 'smell of the ocean' -- influencing cloud formation and protecting themselves against rising seawater temperatures Australian marine scientists have found the first evidence ...

Children's National researcher co-authors study on transitioning cystic fibrosis care

2013-10-24
Children's National researcher co-authors study on transitioning cystic fibrosis care Washington, DC— Children's National pediatrician and researcher, Lisa Tuchman, MD, MPH, co-authored a new study on cystic fibrosis (CF) care that found ...

Diabetes drug metformin with chemo and radiation may improve outcomes in lung cancer patients

2013-10-24
Diabetes drug metformin with chemo and radiation may improve outcomes in lung cancer patients Metformin could serve as a radiosensitizer to treat patients with stage III non-small cell lung cancer SYDNEY, AUSTRALIA—Treating aggressive ...

Penn docs find successful strategy to expand patient participation in hard-to-enroll clinical trials

2013-10-24
Penn docs find successful strategy to expand patient participation in hard-to-enroll clinical trials SYDNEY, AUSTRALIA— Clinical trials are key to finding new cancer treatments, but with patient participation hovering around 5 percent, ...

USC researcher learns how to break a sweat

2013-10-24
USC researcher learns how to break a sweat Without sweat, we would overheat and die. In a recent paper in the journal PLOS ONE, USC faculty member Krzysztof Kobielak and a team of researchers explored the ultimate origin of this sticky, stinky ...

New device stores electricity on silicon chips

2013-10-23
New device stores electricity on silicon chips Solar cells that produce electricity 24/7, not just when the sun is shining. Mobile phones with built-in power cells that recharge in seconds and work for weeks between charges. These are just two ...

Mount Sinai finds value and limitations of patient assistance programs for women with breast cancer

2013-10-23
Mount Sinai finds value and limitations of patient assistance programs for women with breast cancer Nearly 80 percent of women who contacted a patient assistance program had some or all of their needs met, compared with ...

Advanced light source provides a new look at vanadium dioxide

2013-10-23
Advanced light source provides a new look at vanadium dioxide Graphene may command the lion's share of attention but it is not the only material generating buzz in the electronics world. Vanadium dioxide is one of the few known materials that acts ...

Gravitational waves 'know' how black holes grow

2013-10-23
Gravitational waves 'know' how black holes grow Supermassive black holes: every large galaxy's got one. But how did they grow so big? A paper in the journal Science pits the front-running ideas about the growth of supermassive black holes against observational data — a limit ...

LAST 30 PRESS RELEASES:

Osteoporosis treatment benefits people older than 80

Consuming more protein may protect patients taking anti-obesity drug from muscle loss

Thyroid treatment may improve gut health in people with hypothyroidism

Combination of obesity medication tirzepatide and menopause hormone therapy fuels weight loss

High blood sugar may have a negative impact on men’s sexual health

Emotional health of parents tied to well-being of children with growth hormone deficiency

Oxytocin may reduce mood changes in women with disrupted sleep

Mouse study finds tirzepatide slowed obesity-associated breast cancer growth

CMD-OPT model enables the discovery of a potent and selective RIPK2 inhibitor as preclinical candidate for the treatment of acute liver injury

Melatonin receptor 1a alleviates sleep fragmentation-aggravated testicular injury in T2DM by suppression of TAB1/TAK1 complex through FGFR1

Single-cell RNA sequencing reveals Shen-Bai-Jie-Du decoction retards colorectal tumorigenesis by regulating the TMEM131–TNF signaling pathway-mediated differentiation of immunosuppressive dendritic ce

Acta Pharmaceutica Sinica B Volume 15, Issue 7 Publishes

New research expands laser technology

Targeted radiation offers promise in patients with metastasized small cell lung cancer to the brain

A high clinically translatable strategy to anti-aging using hyaluronic acid and silk fibroin co-crosslinked hydrogels as dermal regenerative fillers

Mount Sinai researchers uncover differences in how males and females change their mind when reflecting on past mistakes

CTE and normal aging are difficult to distinguish, new study finds

Molecular arms race: How the genome defends itself against internal enemies

Tiny chip speeds up antibody mapping for faster vaccine design

KTU experts reveal why cultural heritage is important for community unity

More misfolded proteins than previously known may contribute to Alzheimer’s and dementia

“Too much going on”: Autistic adults overwhelmed by non-verbal social cues

What’s driving America’s deep freezes in a warming world?

A key role of brain protein in learning and memory is deciphered by scientists

Heart attacks don’t follow a Hollywood script

Erin M. Schuman wins 2026 Nakasone Award for discovery on neural synapse function and change during formation of memories

Global ocean analysis could replace costly in-situ sound speed profiles in seafloor positioning, study finds

Power in numbers: Small group professional coaching reduces rates of physician burnout by nearly 30%

Carbon capture, utilization, and storage: A comprehensive review of CCUS-EOR

New high-temperature stable dispersed particle gel for enhanced profile control in CCUS applications

[Press-News.org] Team uses forest waste to develop cheaper, greener supercapacitors