Innovative breakthrough in sustainable chemical production
2023-08-22
(Press-News.org)
Carbon capture and utilization (CCU) technologies are crucial for addressing climate change while ensuring economic viability. MES has emerged as a promising approach for CO2 reduction to biofuels and platform chemicals. However, the industrial adoption of MES has been hindered by low-value products like acetate or methane and high electric power demand.
In a new study recently published on 26 July 2023, in the journal Environmental Science and Ecotechnology, researchers from University of Girona conducted a study that focused on electrically efficient MES cells with low ohmic resistance (15.7 mΩ m2). Through a fed-batch mode, alternating high CO2 and hydrogen (H2) availability, they successfully promoted the production of acetic acid and ethanol. Chain elongation resulted in the selective (78% on a carbon basis) production of butyric acid, a valuable chemical used in pharmaceuticals, farming, perfumes, and the chemical industry. At an applied current of 1.0 or 1.5 mA cm−2, the study achieved an impressive average production rate of 14.5 g m−2 d−1 of butyric acid. The key player in the chain elongation process was identified as Megasphaera sp. Inoculating a second cell with the enriched community replicated the butyric acid production rate, but with an 82% reduction in the lag phase. Butyric acid was successfully upgraded to butanol, a valuable biofuel compatible with existing gasoline infrastructure and used as a precursor in pharmaceutical and chemical industries for acrylate and methacrylate production. Solventogenic butanol production was triggered at a pH below 4.8 by interrupting CO2 supply and maintaining specific pH and hydrogen partial pressure conditions. The MES cell design proved highly efficient, with average cell voltages of 2.6–2.8 V and an electric energy requirement of 34.6 kWhel kg−1 of butyric acid produced. Despite some limitations due to O2 and H2 crossover through the membrane, the study identified optimal operating conditions for energy-efficient butyric acid production from CO2.
Highlights
• Low-resistance bioelectro-cells were operated galvanostatically in fed-batch mode.
• Alternating high pCO2 and pH2 promoted bioelectro-CO2 conversion to butyric acid.
• A rate of 14.4 g m−2 d−1 and 78% selectivity were achieved by consuming 35 kWh kg−1.
• Megasphaera sp. carried out chain elongation at the cathode.
• Keeping pH2 > 1.7 atm and pH < 4.8 promoted butanol production in absence of CO2.
In conclusion, this study showcases the potential of bioelectrochemical conversion of CO2 to butyric acid and its subsequent upgrade to butanol in microbial electrolysis cells. The process holds promise for sustainable and economically viable production of valuable chemicals from CO2. Further research and development are crucial to optimize the process for large-scale applications, and with continued advancements, this technology can revolutionize chemical production while mitigating climate change impact.
###
References
DOI
10.1016/j.ese.2023.100303
Funding information
The Spanish Ministry of 478 Innovation and Science (PID2021-126240OB-I00). The European Union’s Horizon 2020 research Marie Skłodowska-Curie grant agreement, project ATMESPHERE (101029266), The Spanish Government (FPU20/01362), The ICREA Academia award, The Research Training grant from the Catalan Government (2021 FISDU 00132), The Catalan Government (2021 SGR01352 and 2021 SGR01142).
About Environmental Science and Ecotechnology
Environmental Science and Ecotechnology (ISSN 2666-4984) is an international, peer-reviewed, and open-access journal published by Elsevier. The journal publishes significant views and research across the full spectrum of ecology and environmental sciences, such as climate change, sustainability, biodiversity conservation, environment & health, green catalysis/processing for pollution control, and AI-driven environmental engineering. The latest impact factor of ESE is 12.6, according to the Journal Citation ReportTM 2022.
END
[Attachments] See images for this press release:
ELSE PRESS RELEASES FROM THIS DATE:
2023-08-22
DETROIT, August 22, 2023 — Today, Detroit Public Schools Community District teachers and coaches completed either the American Heart Association’s Heartsaver® CPR AED (automated external defibrillator) course, which provides the highest quality evidence-based training in the lifesaving skills of CPR, as well as the appropriate use of an AED, or Hands-Only CPR education. Adding lifesavers to the chain of survival in the Detroit community through CPR training and education is a priority for the Detroit Lions Foundation.
“We are honored to use our platform to further bring awareness and education to our community ...
2023-08-22
A team of researchers from Southeast University of China has developed a cutting-edge ultracompact sensing system that leverages the power of spoof surface plasmon resonance (SSPR) technology to enable adaptive and accurate gas detection using a smartphone. The research article detailing this breakthrough, titled "An Ultracompact Spoof Surface Plasmon Sensing System for Adaptive and Accurate Detection of Gas Using a Smartphone," has been published in the prestigious journal Engineering.
Traditional dielectric sensing methods often suffer from signal fluctuations, resulting in reduced sensitivity and accuracy. In response to the growing demand for precise gas detection in ...
2023-08-22
Violent actions intended to provoke opposition to particular communities may paradoxically lead to lasting acceptance, according to a study. On March 15, 2019, a far-right extremist killed 51 Muslims in Christchurch, New Zealand. Immediately following the attacks there was a noticeable increase in public acceptance of the Muslim minority in the country. But was this acceptance sustained? To address this question, Joseph Bulbulia and colleagues used years of data from the New Zealand Attitudes and Values Study, a national longitudinal study. The author’s goal was to estimate the anticipated level of Muslim acceptance if the attacks had not occurred. These ...
2023-08-22
The shells of turtles, tortoises, and sea turtles keep growing as long as the animals live—and some of them live a remarkably long time. Cyler Conrad and colleagues analyzed the shells of five specimens from areas that potentially accumulated anthropogenic uranium through nuclear fallout and/or waste. Unusual uranium signatures were found in a green sea turtle from Enewetak Atoll in the Republic of the Marshall Islands, a desert tortoise from southwestern Utah near the Nevada National Security Site (formerly known as the Nevada Test Site), a river cooter from the Savannah River Site in South Carolina, and a box turtle from Oak Ridge, Tennessee, ...
2023-08-22
Australia has experienced an intense surge in severe Strep A cases, similar to the northern hemisphere wave, despite differences in seasons and circulating respiratory viruses, according to a new study.
The national research project, involving researchers from Murdoch Children’s Research Institute and published in The Lancet Regional Health - Western Pacific, highlighted how the unseasonal increase in case load across the southern hemisphere adds to the need for a safe and effective vaccine against Strep ...
2023-08-22
Engineers in Australia have found a way of making stronger concrete with roasted used-coffee grounds, to give the drink-additive a “double shot” at life and reduce waste going to landfills.
Lead author Dr Rajeev Roychand from RMIT University said the team developed a technique to make concrete 30% stronger by turning waste coffee grounds into biochar, using a low-energy process without oxygen at 350 degrees Celsius.
“The disposal of organic waste poses an environmental challenge as it emits large amounts of greenhouse gases including methane and carbon dioxide, which contribute to climate change,” ...
2023-08-22
Hangzhou, China & Ithaca, N.Y.—Humans aren't the only ones leaving town when city heat becomes unbearable. A study done on 336 cities in China concludes that heat-retaining buildings and paved surfaces are directly related to a loss in bird diversity. These findings from scientists at Zhejiang University and the Cornell Lab of Ornithology are published in the journal Science of the Total Environment.
“The heat-retention characteristic of cities is a well-known phenomenon called the urban heat island ...
2023-08-22
PLYMOUTH MEETING, PA [August 22, 2023] — The National Comprehensive Cancer Network® (NCCN®) today announced the publication of NCCN Guidelines for Patients®: Hodgkin Lymphoma in Children. The book offers a comprehensive analysis of the treatment options, benefits, and risks of care approaches for pediatric Hodgkin lymphoma, one of the most curable forms of childhood cancer, with long-term survival rates of 90% or higher.[1]
This free resource is available online at NCCN.org/patientguidelines and via the NCCN Patient Guides for Cancer App thanks to funding from the NCCN Foundation®.
“When a child is diagnosed ...
2023-08-22
Despite being highly preventable, the Pan American Health Organization estimates cervical cancer kills 35,700 women annually in the Americas, and 80 percent of these cases are in Latin America and the Caribbean (LAC). The recently released BGI Genomics 2023 Global State of Cervical Cancer Awareness Report reveals potential awareness gaps that may contribute to this disproportionate distribution of cervical cancer cases in these regions.
To offer greater insight into the steps needed to improve cervical ...
2023-08-22
The Aging Research and Drug Discovery (ARDD) conference, being held at the University of Copenhagen Aug. 28-Sept. 1, is celebrating 10 years of convening top scientists, venture capitalists, business leaders, and journals engaged in aging research, medicine, and emerging technology.
The conference has grown significantly over its decade-long history. This year’s event kicks off with Longevity Medicine Day which will include speakers like Evelyne Bischof, MD, an expert in internal medicine, oncology, and longevity from Renji Hospital, Shanghai; Michael Basson, ...
LAST 30 PRESS RELEASES:
[Press-News.org] Innovative breakthrough in sustainable chemical production
