STEP Demo supercritical CO2 pilot plant generates electricity for the first time

sCO2 facility on SwRI campus demonstrates more efficient power generation method

2024-05-29

(Press-News.org) SAN ANTONIO — May 29, 2024 —The Supercritical Transformational Electric Power (STEP) Demo pilot plant has generated electricity for the first time using supercritical carbon dioxide (sCO2) power cycles. The $169 million, 10-megawatt sCO2 facility at Southwest Research Institute (SwRI) in San Antonio is demonstrating next-generation power production technology in a project led by GTI Energy in collaboration with SwRI, GE Vernova, the U.S. Department of Energy/National Energy Technology Laboratory (U.S. DOE/NETL), and several industry participants.

“The impact of demonstrating that the sCO2 technology works cannot be overstated,” said SwRI Project Manager Dr. Jeff Moore. “I truly believe this project will change how we approach power generation in the near future.”

For the first time, the pilot plant’s turbine achieved its full speed of 27,000 RPM at an operating temperature of 260°C and generated a small amount of power. Over the next few weeks, the STEP team will slowly ramp up the operating temperature to 500°C and generate 5 megawatts (MWe) of power, enough to power 5,000 homes.

After completion of this first test configuration, the STEP Demo project will enter its final phase. The pilot plant will be reconfigured to boost the power plant’s efficiency and overall energy output. This modification requires the installation of new equipment, as well as a new commission and test phase that will continue into 2025 until the pilot plant is running at full power. At the end of its final phase, the pilot plant will produce 10 MWe hourly, enough to power 10,000 homes.

The STEP Demo pilot plant is one of the largest demonstration facilities in the world for sCO2 technology. Unlike conventional steam power plants, which use water as the thermal medium in power cycles, STEP uses high-temperature sCO2 to increase efficiency by as much as 10% due to its favorable thermodynamic properties. Carbon dioxide is nontoxic and nonflammable, and when CO2 is held above a critical temperature and pressure, it can act like a gas while having the density near that of a liquid.

The pilot plant’s sCO2 turbomachinery is approximately one-tenth the size of conventional power plant components, which shrinks the physical footprint and construction cost of any new facilities. Additionally, the sCO2 power cycles are compatible with many heat sources including concentrated solar power, industrial waste heat, geothermal power and advanced nuclear power plants.

SwRI, GTI Energy, and GE broke ground on the STEP Demo site in 2018. The facility achieved mechanical completion in October 2023, when major subsystems began commissioning.

For more information, visit https://www.swri.org/industry/advanced-power-systems/supercritical-transformational-electric-power-pilot-plant.

END

[Attachments] See images for this press release:

STEP Demo supercritical CO2 pilot plant generates electricity for the first time 2

ELSE PRESS RELEASES FROM THIS DATE:

Risky path to meeting climate targets for Stockholm

2024-05-29

The Swedish capital Stockholm aims to capture more carbon dioxide than is emitted by 2030. Therefore, the city is investing in new technology at a combined heat and power plant. But it is a strategy that has been adopted without sufficient discussion of the risks, says researchers at Linköping university, Sweden. “Stockholm has a very ambitious climate policy. But there’s also been a kind of resignation. This new technology has appeared to offer the promise of a solution. And that’s perhaps why there’s been no critical discussion at all,” says researcher Alexander Olsson at the Department of Thematic ...

Longer freight trains have a higher risk of derailment, new study shows

2024-05-29

In February 2023, 38 cars from a 151-car, 9,300-foot-long freight train derailed in East Palestine, Ohio, leading to the release of hazardous materials that required the evacuation of more than 2,000 residents. In recent years, such longer and heavier freight trains have become more common, primarily driven by fuel efficiency, cost-savings, and emissions reduction measures in the railroad industry. New research in the journal Risk Analysis has confirmed that longer freight trains bring with them a higher risk of derailment. The study found that a 100-car train is more than twice as likely to experience a derailment than ...

The 2024 Global Food Policy Report stresses urgent need for transformative action to achieve sustainable healthy diets and improved nutrition

2024-05-29

Washington DC, May 29, 2024: In the face of growing challenges posed by unhealthy diets, all forms of malnutrition, and environmental constraints, the 2024 Global Food Policy Report (GFPR) — released today by the International Food Policy Research Institute (IFPRI) — underscores the importance of transforming complex global food systems to ensure sustainable healthy diets for all. Progress in reducing undernutrition and micronutrient deficiencies has slowed in low- and middle-income countries, while overweight and obesity has rapidly increased worldwide. Many countries ...

Electrochromic films — like sunglasses for your windows?

2024-05-29

Advances in electrochromic coatings may bring us closer to environmentally friendly ways to keep inside spaces cool. Like eyeglasses that darken to provide sun protection, the optical properties of these transparent films can be tuned with electricity to block out solar heat and light. Now, researchers in ACS Energy Letters report demonstrating a new electrochromic film design based on metal-organic frameworks (MOFs) that quickly and reliably switch from transparent to glare-diminishing green to thermal-insulating red. Hongbo Xu and colleagues used MOFs in their electrochromic film because of the crystalline substances’ abilities to form thin ...

Chocolate’s tasty flavors might pose a risk in other desserts

2024-05-29

What makes chocolate taste and smell so delicious? Chemistry, of course! A variety of molecules work together to create that unmistakable aroma, but those same molecules might carry some unwanted health effects if there are too many around. According to research published in ACS’ Journal of Agricultural and Food Chemistry, while many of the compounds appeared in chocolate in low enough concentrations to be safe, higher amounts were found in some baked sweet treats. When making chocolate, cocoa beans are roasted to help their chocolatey flavors shine. During this process, new molecules ...

The New York Academy of Sciences and the Leon Levy Foundation Announce the 2024 Leon Levy Scholars in Neuroscience

2024-05-29

New York, NY, May 29, 2024 — The New York Academy of Sciences and the Leon Levy Foundation announced today the 2024 cohort of Leon Levy Scholars in Neuroscience, continuing a program initiated by the Foundation in 2009 that has supported 170 fellows in neuroscience. This highly regarded postdoctoral program supports exceptional young researchers across the five boroughs of New York City as they pursue innovative neuroscience research and advance their careers toward becoming independent principal investigators. Nine scholars were competitively selected for a three-year term from a broad pool of applications from more than a dozen ...

The once-welcomed Rohingya refugees now face hostility from the hosts in Bangladesh

2024-05-29

The number of refugees has sharply increased in recent decades, reaching 37.8 million in 2022. Amidst this surge, host communities—locals residing in areas where refugee camps are situated—are also positively and negatively impacted by the refugee influxes. The negative impacts include competition over scarce resources and in the unskilled labor market. While the international media and aid organizations put the spotlight on assisting refugees, the challenges faced by host communities are frequently sidelined. In 2017, over ...

Improving air quality increases forest fires

2024-05-29

If we want cleaner air, fewer forest fires, and less severe climate change, a new UC Riverside study shows we must reduce aerosol pollution and greenhouse gases like carbon dioxide at the same time. The study found that boreal forests in the northern hemisphere are particularly vulnerable to negative effects of cleaning up aerosol pollution. This includes forests in Canada, Alaska, northern Europe, and northern Russia. Aerosols are small particles like dust and sea salt as well as airborne chemicals produced by fossil fuel combustion. They are responsible for poor air quality. The UCR study, published in the journal ...

RNA inhibitor is shown safe and effective in reducing a wide range of cholesterol and triglyceride levels in the blood in Mount Sinai-led clinical trial

2024-05-29

A small interfering RNA (siRNA) investigational therapy that inhibits a gene involved in lipoprotein metabolism has been shown in a clinical trial led by Mount Sinai researchers to significantly reduce levels of different types of cholesterol and triglycerides in individuals with mixed hyperlipidemia, a condition in which fats build up in the blood. In addition to seeing promising preliminary results related to safety and efficacy in clinical trials, the Mount Sinai researchers found the RNA interference (RNAi)-based therapy zodasiran to be a potentially promising option for substantially reducing a number of atherogenic lipoproteins while requiring less frequent ...

Our political debates may not be as antagonistic as we think, study shows

2024-05-29

Spend any time scrolling through social media or news sites and it feels like America is a nation in constant argument. Off-hand remarks often spark fierce screaming matches. Partisanship is up, Gallup tells us, while trust in institutions is down. However, a new study co-authored by Berkeley Haas Assistant Professor Erica R. Bailey suggests this perception may not accurately reflect the nature and frequency of political debates among everyday Americans. In three studies involving nearly 3,000 participants, researchers found most debates ...

STEP Demo supercritical CO2 pilot plant generates electricity for the first time

ELSE PRESS RELEASES FROM THIS DATE:

LAST 30 PRESS RELEASES: